Air Conditioning Inoperative – 2016 Fiat 500X & 2015 Jeep Renegade

“This site contains affiliate links for which OEMDTC may be compensated”

NUMBER: 24-002-16
GROUP: Heating & Air Conditioning
DATE: January 09, 2016

 

THIS BULLETIN SUPERSEDES SERVICE BULLETIN 24-007-15, DATED NOVEMBER 07, 2015, WHICH SHOULD BE REMOVED FROM YOUR FILES. ALL REVISIONS ARE HIGHLIGHTED WITH **ASTERISKS** AND INCLUDE AN UPDATED PART NUMBER.

HELP USING THE wiTECH DIAGNOSTIC APPLICATION FOR FLASHING AN ECU IS AVAILABLE BY SELECTING “HELP” THEN “HELP CONTENTS” AT THE TOP OF THE wiTECH DIAGNOSTIC APPLICATION WINDOW.

THE wiTECH SOFTWARE IS REQUIRED TO BE AT THE LATEST RELEASE BEFORE PERFORMING THIS PROCEDURE.

 

SUBJECT:

Air Conditioning Inoperative

 

OVERVIEW:

This bulletin involves replacing the Manual Climate Control Module.

 

MODELS:

2016 (FB) Fiat 500X
2015 (BU) Jeep Renegade

 

NOTE: This bulletin applies to vehicles within the following markets/countries: NAFTA, EMEA.

NOTE: This bulletin applies to vehicles built on or before June 17, 2015 (MDH 0617XX).

 

SYMPTOM/CONDITION:

A small number of customers may experience the loss of air conditioning operation (A/C compressor will not turn on).

 

DIAGNOSIS:

Using a Scan Tool (wiTECH) with the appropriate Diagnostic Procedures available in TechCONNECT, verify all systems are functioning as designed. If DTCs or symptom conditions, are present other than the symptom condition listed above, record the issues on the repair order and repair as necessary before proceeding further with this bulletin.

If the customer describes the symptom/condition listed above, perform the Repair Procedure.

 

PARTS REQUIRED:

Qty. Part No. Description
1 6CW62LXHAA Climate Control Module (FB)
1 6CY58LXHAA Air Conditioning Inoperative - 2016 Fiat 500X & 2015 Jeep Renegade | small light Climate Control Module (BU)

 

REPAIR PROCEDURE:

  1. Replace the Manual Climate Control Module.Refer to the detailed service procedures available in DealerCONNECT> TechCONNECT under: Service Info> 24 – Heating and air Conditioning > Controls > CONTROL, A/C and Heater > Removal and Installation.
  2. Clear all DTCs that may have been set in any module due to reprogramming. The wiTECH application will automatically present all DTCs after the flash and allow them to be cleared.

 

POLICY:

Reimbursable within the provisions of the warranty.

 

TIME ALLOWANCE:

Labor Operation No: Description Skill Category Amount
24-50-10-9B Module, Heating Ventilation Air Conditioning (HVAC) – Replace (2 – Skill Level) 07 – A/C and Heating 0.4 Hrs.

 

FAILURE CODE:

ZZ Service Action

 


https://www.nhtsa.gov/recalls?nhtsaId=10119638

 

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [34.64 KB]

 


 

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [34.42 KB]

 


 

Bestseller No. 1
EZ Chill Auto Air Conditioning R-134A Refrigerant Recharge Kit - 18 OZ
  • UNABLE TO SHIP THIS ITEM TO CALIFORNIA and WASHINGTON
  • All in one solution to restore lost refrigerant and oil in automotive air conditioning systems
  • Contains system safe leak sealer additive that seals common A/C leaks in rubber hoses, gaskets and O-rings
  • Built in disposable recharge hose
  • No tools required
Bestseller No. 2
SuperTech R-134a Refrigerant Automotive use in a 12oz Self-Sealing Container (3 Pack)
  • USA Made - All R134a is brand new and made in the USA to the highest purity standards. This can be used to recharge 100% of R134a air conditioning systems.
  • NEW GAS - SuperTech gas is brand new and never reclaimed or recycled. We purchase our R134a multiple times per year ensuring you get fresh made refrigerant. Old refrigerants can begin to rust and can cause performance issues if used.
  • SSV CANS - Our cans are equipped with the 50 State compliant self-sealing valve design. You can store partially used R134a cans. Note, older can taps may not work on this valve type and you may need to purchase a R134a can tap to work with all SSV cans
  • Complies with Section 612 of the EPA Clean Air Act
  • Returns: This item is considered a HazMat Material and as such is not returnable. It requires hazmat certification to ship. Amazon does not supply a Return label and the seller will not supply return labels for this type of products.
Bestseller No. 3
Leak Saver 134a Replacement Refrigerant for MVAC, HVACR, Automotive - R-134a for MVAC use in a 8-Ounce Container - 3 Pack
  • WORKS WITH ALL 134a SYSTEMS: Our 134a Replacement Refrigerant is compatible with all systems and lubricants that are designed to be used with 134a refrigerant or that have been retrofitted to use 134a. It can be used in cars, trucks, refrigerators, RVs, boats, tractors, combines, ice machines, milk processing equipment, and any other equipment calling for R-134a. You must follow all EPA guidelines when handling this refrigerant.
  • COLDER FORMULA WITH LOWER HEAD PRESSURES: Our refrigerant is a specially engineered hydrocarbon formula that operates at a lower head (high side) pressure than standard 134a. This can allow your compressor to run smoother and have improved cooling and performance properties. This is our coldest and highest performing refrigerant formula. When charging, our 134a Replacement Refrigerant is easily installed using the same pressure parameters as standard 134a.
  • USES LESS REFRIGERANT BY WEIGHT: Our 134a Replacement Refrigerant is physically lighter than standard 134a refrigerant. Each 8oz can of 134a Replacement Refrigerant is equal to 21oz of standard 134a refrigerant (a 1:2.6 weight ratio). That means that if you want to add 12oz of standard 134a refrigerant to a system, you will only need to add 4.6oz of our 134a Replacement Refrigerant. This translates to using up to 60% less refrigerant for a proper charge.
  • PROVEN FORMULA THAT IS ENVIRONMENTALLY SAFE: The Leak Saver 134a Replacement Refrigerant formula is 100% USA Made. It is designed to be a climate-friendly green alternative to standard 134a and is non-ozone depleting and has zero Global Warming Potential (GWP). On the other hand, standard R-134a is an HFC (hydrofluorocarbon) greenhouse gas and has a high (GWP). Please note that this refrigerant is flammable and has been safely sold for all the listed applications for over 28 years.
  • YOUR SATISFACTION IS OUR PRIORITY: We stand 100% behind the effectiveness of our products. If for any reason you are not satisfied with your product, please contact us, and we will make it right.
SaleBestseller No. 4
Bestseller No. 5
InterDynamics A/C Pro ACP-102 Ultra Synthetic A/C Recharge R-134a Car Refrigerant - 12 OZ
  • Replaces lost R-134a refrigerant and oil in automotive A/C system
  • System safe stop leak sealer stops most common A/C leaks with hoses, gaskets and O-Rings
  • Special anti-wear additives extend system life and improve performance
  • Contains R-134a gas which is acceptable for use in motor vehicle A/C (MVAC) systems
  • Complies with Section 612 of the EPA Clean Air Act, EPA Compliant in Self Sealing Cans
Bestseller No. 6
Sub-Zero Synthetic Refrigerant R-134a (14 ounces)
  • Replaces lost R-134a refrigerant and oil in automotive A/C system
  • Formulated with COOL BOOST technology to provide up to 18% colder air and eliminate moisture buildup
  • System-safe leak sealer additive seals common A/C leaks in rubber hoses, gaskets and O-rings
  • Contains R-134a gas which is acceptable for use in motor vehicle A/C (MVAC) systems
  • Complies with Section 612 of the EPA Clean Air Act, EPA Compliant in Self Sealing Cans
SaleBestseller No. 7
AC PRO Chemours R-134a Refrigerant Freon for MVAC use in a 12-Ounce Self-Sealing Container (3 Pack)
  • Freon(TM) 134a plus UV leak detector helps save mobile AC professionals time and money by combining the application of UV and refrigerant into one step to identify hard-to-find R-134a refrigerant leaks!
  • Freon(TM) 134a UV is MADE IN THE USA and contains a high-technology dye formulation that meets the stringent requirements of SAE J2297 and AHRI700. The dye has been approved and used by OEMs, dealer service networks, and independent service shops for years.
  • Add Freon(TM) 134a UV to a mobile AC system that does not contain any dye, start up the compressor, and let the dye do the work for you. The dye mixes with the lubricant and is quickly distributed through the system and helps to identify the R-134a leak in no time!
Bestseller No. 8
A/C Pro Ultra Synthetic A/C Recharge R-134a Kit (20 ounces)
  • UNABLE TO SHIP THIS ITEM TO CALIFORNIA and WASHINGTON
  • Replaces lost R-134a refrigerant and oil in automotive A/C system to protect and extend system life
  • Comes with reusable extra-long braided charging hose and large gauge with trigger dispenser for easy, convenient, and accurate recharging
  • Formula with 2X cooling boosters vs the next leading brand of A/C recharge kits: independently tested to deliver the coldest air from your vehicle's A/C
  • Contains R-134a gas which is acceptable for use in motor vehicle A/C (MVAC) systems
Bestseller No. 9
Arctic Freeze Auto A/C Recharge R-134a Synthetic Refrigerant for MVAC use in a 14-Ounce Self-Sealing Container with Stop Leak - Includes 14oz R134A & Recharge Hose - NO Gauge
  • For MVAC use in a 14-ounce self-sealing container with Stop Leak
  • Cool Boost technology delivers colder air -- Contains approximately 12 oz. of R-134a and 2 oz. of additives
  • Contains leak sealer to seal common A/C leaks in rubber hoses, gaskets, and O-rings
  • Contains moisture and acid buildup eliminator which helps extend A/C system life
  • Packaging May Vary as Shown in Last Picture -- Reusable recharge hose with push button dispenser included -- NO GAUGE
Bestseller No. 10
AC PRO R-134a Certfired Auto Air Conditioning for MVAC in 12oz Self Sealing Can (3 Cans)
  • Replaces lost R-134a refrigerant and oil in automotive A/C system
  • Contains R-134a gas which is acceptable for use in motor vehicle A/C (MVAC) systems

Last update on 2024-02-01 / Affiliate links / Images from Amazon Product Advertising API

This product presentation was made with AAWP plugin.

Leave a Comment

1
Share to...